Touareg electric tailgate lift install manual

By HansShoW | 11/03/2020 |

Features

The intelligent electric tailgate is suitable for high-end luxury cars. It has the functions of hand-in-one opening, intelligent anti-pinch, intelligent height adjustment, etc. The driver can control tailgate with the car key tailgate button. It is easy to control and practical.

Electric tailgate functions

Easy to open
The electric tailgate can be controlled by the tailgate switch and the vehicle key.

Intelligent anti-pinch
When the electric tailgate is opened or closed, obstacles are encountered, and the tailgate can stop running to protect the user.

Listing

HOW TO INSATLL IT?

1. Original car appearance
2. Remove the tripod.
3. Remove the 2 screws as shown.
4. Remove the 2 screws.
5. Remove tailgate LED light.
6. Remove the trim.
7. Remove the big trim effect.
8. Remove the trim as shown.
9. Remove the original strut
with screwdriver.
10. Remove original bracket.
11. Install our bracket (L left, R right.)
12. Install our strut. (L left, R right)
13. Remove original rubber
stopper.

14. Pass the strut wire through The hole as shown

15.Install the rubber stopper.
16. Remove the original tailgate lock plug,
connect it with our lock plug.
17. Remove original handle button
Signal plug, connect it with our
handle plug.
18. Remove the latch trim.
19.Remove the original latch.
20. Install our electric latch.
21. Fixing the latch motor here.
22.Connect the GND wire here with screw.
23. Remove the left trim as shown.
24. Connect our power wire to a 20A constant
Electric power fuse.
25. Open the steering wheel
Trim as shown
27.Remove this screws.
28. Remove this plug, connect
it to our related plug.
29. Front wiring diagram.
30. Front wiring diagram.
31.Wiring the front wire in trunk
as shown.
32. Pass through the wire to the tube
33. Connect the related plug to
the controller.
34.Make a hole here and install the tailgate
Button.
35. Before recover all panel, check all the wire
and connected right. Power on the system.
Please use your hand close the tailgate at the
first time. Then you can use the car key to control
the tailgate.

Installation Precautions

1.All harness ports, control boxes,
poles, etc. can not energized until
they are installed.
2.Pay attention to the direction of
power take-off, must be connected
to 20A constant electric fuse.
3.When installing the wire, it must
be operated with the engine off
and the car key unplugged
4.If there is a situation where the
tailgate cannot be closed, remove
the rubber plug in the lock head.

Fault phenomenon&Solution

Remarks: After installing the electric tailgate lift, you must manually close it once and then open it. Finally, the installation is complete.

How to use the remote control: Press the key unlock button 3s to open or close the tailgate; Cab button: Press to open the tailgate and press it to close the tailgate.

Disclaimer: The problems and losses caused by improper installation and improper use are not covered by our company’s warranty

Posted in Car tailgate & power running board news

Leave a Comment